The method of random balance for studying the influence of excipients quantities on technological parameters of tablets based on Origanum vulgare L. dry extract

Keywords: Origanum vulgare L., dry extract, excipients, compression mixture, tablets, method of random balance

Abstract

The aim. The aim of the research was to study the influence of excipients amount on the technological parameters of the compression mixture and tablets based on dry extract of Origanum vulgare L. herb using the method of random balance.

Materials and methods. Objects of the study – Origanum vulgare L. herb dry extract, 8 excipients that have been studied at two quantitative levels. The tablets were prepared by direct compression method. The formulations were designed according to the method of random balance. The technological parameters of the compression mixture and tablets based on Origanum vulgare L. herb dry extract have been studied as a function of quantitative factors: silicon, magnesium carbonate basic, dioxide magnesium aluminometasilicate (Neusilin S1®), isomalt (GalenIQ™720), F-melt® Type C (co-spray dried excipients), sucralose, berry flavor and citric acid.

Results and discussion. The increase in the amount of Neusilin S1®, GalenIQ™720 and F-melt®, and the decrease in the amount of magnesium carbonate basic and silicon dioxide improved the flowability expressed by the Hausner ratio. Results of bulk density and tapped density of the compression mixture depended on the quantities of GalenIQ™720 and F-melt®. All formulations of the prepared tablets had the rapid disintegration and ranging from 6 to 15 minutes. Resistance for crushing and friability tablets’ were improved with a decrease in the amount of silicon dioxide and increase in the amount of Neusilin S1®, F-melt® and sucralose. Higher resistance to moisture of tablets based on Origanum vulgare L. dry extract was obtained by using Neusilin S1®, F-melt® and sucralose on the upper levels.

Conclusions. The tablets based on Origanum vulgare L. herb dry extract were successfully manufactured by direct compression method. The random balance method enabled us to identify the most significant quantitative factors to optimize their composition in the tablets based on the dry extract of Origanum vulgare L. herb.

Downloads

Download data is not yet available.

Author Biographies

Svitlana Chernetska, I. Horbachevskyi Ternopil National Medical University

Department of Pharmacy Management, Economics and Technology

Natalia Beley, I. Horbachevskyi Ternopil National Medical University

Department of Pharmacy Management, Economics and Technology

Mariana Demchuk, I. Horbachevskyi Ternopil National Medical University

Department of Pharmacy Management, Economics and Technology

References

Influenza (Seasonal) (2018). World health organization. Available at: https://www.who.int/news-room/fact-sheets/detail/influenza-(seasonal)

Pelucchi, C., Grigoryan, L., Galeone, C., Esposito, S., Huovinen, P., Little, P., Verheij, T. (2012). Guideline for the management of acute sore throat. Clinical Microbiology and Infection, 18, 1–27. doi: http://doi.org/10.1111/j.1469-0691.2012.03766.x

Oxford, J. S., Leuwer, M. (2011). Acute sore throat revisited: clinical and experimental evidence for the efficacy of over-the-counter AMC/DCBA throat lozenges. International Journal of Clinical Practice, 65 (5), 524–530. doi: http://doi.org/10.1111/j.1742-1241.2011.02644.x

Angotoeva, I. B. (2015). Differentsial'naya diagnostika boley v gorle. Meditsinskiy sovet, 15, 42–46.

Voloshyn, O. I., Harnyk, T. P., Voloshyna, L. O., Vasiuk, V. L. (2013). Liky roslynnoho pokhodzhennia v klinitsi vnutrishnikh khvorob − odyn iz vazhlyvykh shliakhiv vyrishennia problemy komorbidnosti (Ohliad literatury ta vlasni doslidzhennia). Fitoterapiia, 1, 4–9.

Mikheev, A. A. (2017). Prospects of application of vegetable oils as antifungal agents (Literature review). Zaporozhye Medical Journal, 19 (2), 221–226. doi: http://doi.org/10.14739/2310-1210.2017.2.95745

Shayista, Ch., Zahoor, A. K., Phalestine, S. (2013). Medicinal importance of genus Origanum: A review Journal of Pharmacognosy and Phytotherapy, 5 (10), 170–177.

Brdjanin, S., Bogdanovic, N., Kolundzic, M., Milenkovic, M., Golic, N., Kojic, M., Kundakovic, T. (2015). Antimicrobial activity of oregano (Origanum vulgare L.): And basil (Ocimum basilicum L.): Extracts. Advanced Technologies, 4 (2), 5–10. doi: http://doi.org/10.5937/savteh1502005b

Chernetska, S., Bely, N. (2020). Preparation and research of Oregano herb dry extract. Sciences of Europe, 55, 10–12.

Chernetska, S. B., Beley, N. M. (2019). Analysis of the pharmaceutical market of medicines for the treatment of throat diseases. Fitoterapia, 1, 34–37. doi: http://doi.org/10.33617/2522-9680-2019-1-34

Chernetska, S. B., Beley, N. M. (2018). Prospects for a creation of new drugs based on Oregano (Literature review). Fitoterapia, 1, 25–28.

Zivorad, R., Lazic. (2004). Design of experiments in chemical engineering. A practical guide. Weinheim: Wiley-VCH.

Hroshovyi, T. A., Martseniuk, V. P., Kucherenko, L. I., Vronska, L. V., Hureieva, S. M. (2008). Matematychne planuvannia eksperymentu pry provedenni naukovykh doslidzhen v farmatsii. Ternopil: Ukrmedknyha, 377.

State Pharmacopoeia of Ukraine. Vol. 2 (2015). Kharkiv: Derzhavne pidpriemstvo. Ukrayinskiy naukoviy farmakopeyniy tsentr yakosti likarskih zasobiv, 1128.

Barchuk, O. Z., Hroshovyi, T. A., Zaliska, O. M., Shalata, V. Yа., Maksymovych, N. M. (2018). Study of the influence of quantitative factors in creation of tablets of extracts of bilberry leaves, goat’s rue herb and taurine by direct compression method. Pharmaceutical review, 4, 42–48. doi: http://doi.org/10.11603/2312-0967.2018.4.9706

Darzuli, N. P., Hroshovyi, T. A. (2018). Study of quantitative factors on technological properties of compression mixture and tablets of round-leaved wintergreen extract. Pharmaceutical review, 3, 45–51. doi: http://doi.org/10.11603/2312-0967.2018.3.9377

Beley, S. Ya., Hroshovyi, T. A., Beley, N. M. (2018). Substantiation of selection of excipients for obtaining tablets based on Malva Sylvestris L. and Plantago Lanceolata L. dry extracts. Pharmaceutical review, 3, 37–44. doi: http://doi.org/10.11603/2312-0967.2018.3.9358

Denys, A. I., Hroshovyi, T. A. (2012). Doslidzhennia vplyvu kilkisnykh faktoriv na farmako-tekhnolohichni vlastyvosti tabletok ekstraktu lystia topoli kytaiskoi. Pharmaceutical review, 3, 64–66.

Azad, M., Moreno, J., Davé, R. (2018). Stable and Fast-Dissolving Amorphous Drug Composites Preparation via Impregnation of Neusilin® UFL2. Journal of Pharmaceutical Sciences, 107 (1), 170–182. doi: http://doi.org/10.1016/j.xphs.2017.10.007

Juneja, P., Kaur, B., Odeku, O. A., Singh, I. (2014). Development of Corn Starch-Neusilin UFL2 Conjugate as Tablet Superdisintegrant: Formulation and Evaluation of Fast Disintegrating Tablets. Journal of Drug Delivery, 2014, 1–13. doi: http://doi.org/10.1155/2014/827035

Barrios-Vazquez, S. C., Villafuerte-Robles, L. (2013). Functionality of GalenIQ 721 as excipient for direct compression tablets. Journal of Applied Pharmaceutical Science, 3 (4), 8–19.

Chaudhary, S. A., Chaudharya, A. B., Mehta, T. A. (2010). Excipients Updates for Orally Disintegrating Dosage Forms. International Journal of Research in Pharmaceutical Sciences, 1 (20), 103–107.


👁 556
⬇ 267
Published
2021-03-31
How to Cite
Chernetska, S., Beley, N., & Demchuk, M. (2021). The method of random balance for studying the influence of excipients quantities on technological parameters of tablets based on Origanum vulgare L. dry extract. EUREKA: Health Sciences, (2), 73-81. https://doi.org/10.21303/2504-5679.2021.001664
Section
Pharmacology, Toxicology and Pharmaceutical Science